Product ID:SHELL SOL 140 HT
MSDS Date:07/20/1994
FSC:6850
NIIN:00-274-5421
MSDS Number: BJKML

Emergency Phone: 713-473-9461 (24 HOUR EMERGENCY)

Info Phone: 713-241-4819

Preparer: G.A.VAN GELDER

Cage: 54527

Telephone: 800-231-6950

Cage: 54527

NAPHTHA, MEDIUM ALIPHATIC

CAS: 64742-88-7

Fraction By Weight: 100%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM

LD50 LC50 Mixture:LD50 (ORAL RAT) IS >25 ML/KG
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE-EYE:ALMOST NONIRRITATING.
SKIN:MILD IRRITATION. INHALATION: NOSE, THROAT & RESPIRATORY
IRRITANT. HIGH VAPOR AMOUNTS MAY RESULT IN CNS DEPRESSION AND
DEATH. INGESTION: VOMITING, NAUSEA, ASPIRATIO N PNEUMONITIS,
CHEMICAL PNEUMONITIS, PULMONARY EDEMA OR DEATH. CHRONIC-SKIN:
DERMATITIS.
Explanation of Carcinogenicity:NONE OF THE COMPOUNDS IN THIS PRODUCT IS
LISTED BY IARC, NTP, OR OSHA AS A CARCINOGEN.
Effects of Overexposure:EYE: TEMPORARY REDNESS & PAIN. SKIN:
IRRITATION. INHALATION: HEADACHE, DROWSINESS, DIZZINESS, CONFUSION,
NAUSEA, TREMORS, INCOORDINATION & DIFFICULTY BREATHING. INGESTION:
SWELLING OF ABDOMEN, HEADACH E, DEPRESSION. IF LIQUID IS ASPIRATED
INTO LUNGS DEATH CAN RESULT.
Medical Cond Aggravated by Exposure:PRE-EXISTING EYES, SKIN, OR
RESPIRATORY DISORDERS MAY BE AT INCREASED RISK FROM EXPOSURE.

First Aid:INHALATION: MOVE TO FRESH AIR. GIVE OXYGEN IF HARD TO BREATH
& CPR IF NO BREATHING. SEE DOCTOR. EYES:FLUSH WITH WATER FOR 15
MINUTES HOLDING EYELIDS OPEN. SEE DOCTOR. SKIN: REMOVE CONTAMINATED
CLOTHES . FLUSH THEN WASH WITH SOAP AND WATER. INGESTION: DO NOT
INDUCE VOMITING. IF VOMITING OCCURS NATURALLY, KEEP HEAD BELOW HIPS
TO PREVENT ASPIRATION OF LIQUID INTO THE LUNGS. SEE DOCTOR
IMMEDIATELY.

Flash Point Method:TCC
Flash Point:145F,63C
Autoignition Temp:Autoignition Temp Text:205 C
Lower Limits:1
Upper Limits:7
Extinguishing Media:USE WATER FOG, CO2, FOAM, OR DRY CHEMICAL. DON'T
USE DIRECT WATER STREAMS. PRODUCT CAN FLOAT/REIGNITE ON WATER
SURFACE
Fire Fighting Procedures:CAUTION. COMBUSTIBLE. DON'T ENTER CONFINED
AREA WITH OUT FULL BUNKER GEAR & POSITIVE PRESSURE NIOSH APPROVED
SCBA. COOL FIRE EXPOSED CONTAINER WITH WATER.
Unusual Fire/Explosion Hazard:COOL HEAT EXPOSED CONTAINERS AND AREA
WITH WATER SPRAY. EXPOSED CONTAINERS SHOULD BE COOLED TO PREVENT
VAPOR PRESSURE BUILDUP.

Spill Release Procedures:SPILL-SMALL SPILL:SOAK UP LIQUID WITH INERT
ABSORBENT MATERIAL. PUT IN SUITABLE, COVERED, LABELLED CONTAINER.
FLUSH AREA WITH WATER TO REMOVE TRACE RESIDUE.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE-STORE IN COOL, DRY, WELL
VENTILATED AREA, OUT OF DIRECT SUNLIGHT & AWAY FROM IGNITION
SOURCES. BOND & GROUND EQUIPMENT.
Other Precautions:STORE-DO NOT CUT, GRIND, DRILL OR WELD NEAR CNTNRS.
VAPORS MAT ACCUMULATE & TRAVEL TO IGNITION SOURCES DISTANT FROM
HANDLING SITE; FLASH-FIRE CAN RESULT. EXTINGUISH PILOT LIGHTS &
CIGARETTES.

Respiratory Protection:AVOID CHRONIC BREATHING OF VAPORS. IF VAPORS
EXCEED PEL(TLV), USE NIOSH/MSHA APPROVED ATMOSPHERE-SUPPLYING OR AN
AIR- PURIFYING (ORGANIC VAPORS) RESPIRATOR.
Ventilation:USE EXPLOSION-PROOF VENTILATION AS REQUIRED TO CONTROL
VAPOR CONCENTRATIONS.
Protective Gloves:CHEMICAL RESISTANT GLOVES
Eye Protection:SAFETY GLASSES OR GOGGLES
Other Protective Equipment:CHEMICAL RESISTANT CLOTHING AS NECESSARY TO
PREVENT SKIN CONTACT. AN EMERGENCY EYEWASH AND SHOWER SHOULD BE
AVAILABLE.
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES. DO NOT WEAR CONTAMINATED CLOTHING OR
FOOTWEAR.
Supplemental Safety and Health
AVOID PROLONGED OR REPEATED EXPOSURE. DO NOT GET ON SKIN OR IN EYES. DO
NOT BREATHE VAPORS OR MISTS. AIR-DRY CONTAMINATED CLOTHING IN A
WELL VENTILATED AREA THEN LAUNDER BEFORE REUSING.

HCC:V4
Boiling Pt:B.P. Text:350F,177C
Melt/Freeze Pt:M.P/F.P Text:NOT GIVEN
Vapor Pres:<5 @ 100F
Vapor Density:5.3(AIR=1)
Spec Gravity:0.79 (WATER=1)
Evaporation Rate & Reference:0.03 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT COLORED LIQUID. HYDROCARBON ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS
Stability Condition to Avoid:HIGH TEMPERATURES, SPARKS, AND OPEN FLAMES
Hazardous Decomposition Products:CARBON MONOXIDE AND UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED DURING COMBUSTION.

Waste Disposal Methods:DISPOSAL SHOULD BE MADE IN ACCORDANCE WITH ALL
APPLICABLE FEDERAL, STATE AND LOCAL LAWS AND REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.